2018 JEEP GRAND CHEROKEE reports

ENGINE

The contact owns a 2018 Jeep Grand Cherokee. The contact stated that while taking the vehicle to a service center for an oil change, the oil filter plastic housing unexpectedly warped after the oil change. The contact stated that after the failure, smoke was coming from the vehicle, and an oil odor was coming from the vents when the heat was activated. The contact stated that after the vehicle was parked at the residence, there was a trail of oil coming from the vehicle. The failure mileage was 96,685.

ENGINE

Sudden loss of power while driving 75mph in the fast lane on [XXX] in [XXX]. My 2018 with the 3.0ltr Eco diesel engine was involved in a sever life-threatening event That caused my engine to fail while driving and I request immediate corporate escalation! On XXX while driving in the fast lane after just fueling up not more than 15-20min prior. my vehicle suffered, for no known reason, a catastrophic engine failure. There are no codes to be found (so said the dealer) "we cant tell you what happened to your engine", the dealer has sent me in writing. All of the sudden the dashboard read, " PULL OVER AND PUT IN PARK IMMEDIATELY".... I lost all power and was fortunate to ba able to catch an off-ramp to get off of the highway. After a 350mi tow to the walnut creek chrysler/jeep dealer. They were unable to tell me what went wrong or why a simple oil/ check engine light never happened to alert the operator? I was then told it would be a $35k engine replacement? most diesel engines historically run 250,000 to 500,000 miles and up with regular maintenance... I purchased this showroom quality vehicle from a private seller... never having even been towed 1 single time in its life before this event. I need to know what recourse that may exists for me regarding this most tragic and unsafe situation... So foreign investment groups can purchase USA auto factories and turn them into horible products... and that's okay? I have driven well over 1 million miles in my lifetime. I currently own 2 trucks, an Audi A3, 8 motorcycles, and a sprinter van RV. I formerly owned an Eagle tour coach. I am an experienced rider driver of nearly 40yrs on the road. please help [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

VEHICLE SPEED CONTROL

system works intermittently--sometimes won't engage--other times suddenly cuts off when engaged

SEATS

In approximately early to mid-August 2026, I was driving my 2018 Jeep Grand Cherokee at approximately 40 mph when the passenger-side Active Head Restraint (AHR) suddenly deployed without any collision, rear impact, or other event that should have caused it to deploy. There was no passenger in the seat at the time, so fortunately no one was struck or injured. The vehicle had approximately 55,179 miles at the time of the incident. Its current mileage is 55,279 miles. Following the unexpected deployment, the passenger-side head restraint developed a persistent rattling condition. I brought the vehicle to Naples Chrysler Dodge Jeep Ram for inspection. The dealer advised that the head restraint would need to be replaced and provided an estimate of approximately $1,001.95, including parts and labor. I subsequently contacted Jeep Customer Care regarding the problem. My case was assigned Case Number 97938645 and was initially characterized as a high-priority Repair Cost Assistance matter. I was later advised that Goodwill assistance was not available for my 2018 vehicle. I am submitting this complaint because the Active Head Restraint is a safety device, and it spontaneously deployed while the vehicle was traveling approximately 40 mph, without a collision or rear impact. I am concerned that an inadvertent deployment of this safety device could strike and injure an occupant or potentially create a dangerous distraction or loss-of-control situation if it occurs while the vehicle is moving. I understand that certain 2014–2018 Jeep Grand Cherokee vehicles have been subject to FCA warranty-related action concerning Active Head Restraint inadvertent deployment. I am not asserting that my particular VIN qualifies for that coverage; I am reporting the actual safety event and asking NHTSA to consider it in evaluating this potential safety issue.

POWER TRAIN · ELECTRICAL SYSTEM · ENGINE

Subject: 2018 Jeep Grand Cherokee – Sudden Loss of Power, PCM Failure, Electrical Failures, and Concern Regarding Recall-Related Symptoms I am filing this complaint because my 2018 Jeep Grand Cherokee experienced a sudden and unexpected loss of power while I was driving, and I am very concerned about the safety implications and the possible connection to the recall-related electrical problems associated with this vehicle. Before the final failure, my Jeep had been experiencing electrical and starting problems. The alternator failed, the batteries went bad, and I had already paid for multiple diagnostics and repairs. At the time, we did not understand that these problems could potentially be leading to or connected with a PCM failure. I have spent approximately $800 on diagnostics and parts trying to determine and repair the cause of these issues. The most serious incident occurred when I was driving near a school and approaching a stop sign. The Jeep suddenly began losing power and would no longer operate normally. I did not receive an adequate warning that the vehicle was about to completely shut off. The dashboard/screen began flashing, electrical functions began going out, and the vehicle progressively lost power. I was able to slowly move the Jeep toward the right side of the road before it completely shut off. The Jeep then would not start again. This was extremely frightening because the vehicle lost power while I was operating it in an area where there were other vehicles and children nearby. I was concerned about my ability to safely get the vehicle off the roadway and about what could have happened if the Jeep had completely lost power in moving traffic or at a higher speed. The vehicle has since been diagnosed as having a PCM failure. I have already paid for diagnostics rather than simply bringing the vehicle in without any prior information about the problem. Despite this, the Jeep dealershiphas my vehicle now to determine if this is part of recall

POWER TRAIN · VEHICLE SPEED CONTROL

I am reporting repeated drivetrain and transmission failures involving my 2018 Jeep Grand Cherokee SRT. The problems began with failure of the driveshaft carrier bearing, which was replaced with a brand-new component by an independent mechanic. The transfer case subsequently required replacement and was replaced with a brand-new unit by a reputable dealership. After these repairs, the original transmission mechanically failed at approximately 99,000 miles. I replaced it with a transmission from a 2021 model that had approximately 45,000 miles. That transmission then failed after only approximately 5,000 miles of use in my vehicle. I am now having another transmission installed, meaning my Jeep is receiving its third transmission. By the completion of these repairs, I will have spent more than $20,000 addressing drivetrain and transmission failures. I am concerned that an underlying drivetrain, transmission, electronic/control, or other vehicle-related condition may be contributing to these repeated failures. Replacing major drivetrain components has not resolved the problem, and I am concerned about the safety and reliability of the vehicle. I am also aware of a similar situation involving my niece’s 2021 Dodge Durango R/T with approximately 60,000 miles. Her vehicle is also on its third transmission, with brand-new replacement transmissions being installed under warranty. I am requesting that NHTSA review these repeated failures and determine whether similar transmission or drivetrain problems have been reported and whether they may indicate a safety-related defect or broader pattern.

AIR BAGS

I own a 2018 Jeep Grand Cherokee Limited. The driver's-side Active Head Restraint (AHR) suddenly deployed/opened without the vehicle being involved in a collision or rear impact. The head restraint separated/opened with significant force and will not remain in its normal position. I am not aware of any warning lights, warning messages, or other symptoms before the head restraint deployed. This creates a serious safety concern because the Active Head Restraint is positioned directly behind the driver's head and neck. An unexpected deployment while the vehicle is occupied or being driven could cause injury to the driver's head or neck and could also startle or distract the driver. The vehicle has not been involved in an accident that would have caused the Active Head Restraint to deploy. The failed head restraint/component is available for inspection. After researching the failure, I discovered that FCA/Stellantis has previously issued technical service and warranty information concerning inadvertent Active Head Restraint deployment, including TSB 23-018-20 and related AHR warranty-extension programs. I also learned that NHTSA investigated inadvertent Active Head Restraint deployments involving Jeep Grand Cherokee vehicles, including later model-year vehicles. I contacted FCA/Stellantis regarding the failure. I was initially referred to a Jeep dealership, and I am continuing to request that Stellantis review the failure and determine whether it falls under one of its Active Head Restraint warranty-extension programs.

POWER TRAIN · ELECTRICAL SYSTEM · ENGINE

The Jeep was giving me a warning sign. It said stop slowly. Your jeep will shut off so I replaced the two batteries. As my Mechanic told me I replaced the alternator. I also replaced the ground wires. Nothing is making my jeep start. We ran the codes on the jeep and it came back as a U0100 code with the PCM system. No connection error. we looked up the recall information and a recall popped up for this 2018 jeep Grand Cherokee. I am being told that I am not affected by this recall.. the jeep was giving warning Saenz before I replaced the battery and alternator. After that. It did not give warning Saenz Anymore. It’s just completely Shut Off With no warning. Leaving me on the side of the road stranded twice. It will not start and it is reading these codes.

ENGINE AND ENGINE COOLING

The contact owns a 2018 Jeep Grand Cherokee. The contact stated that since the vehicle was purchased, there was an abnormally strong coolant odor coming from the vehicle. The dealer was notified of the failure and informed the contact that the coolant reservoir was recently refilled, and the odor might be due to an overflow. The contact stated that the failure persisted, and the vehicle was taken to the dealer, where the water pump was replaced. The contact stated that the water pump had been replaced approximately nine times under warranty due to the strong coolant odor and a water pump leak; however, the failure persisted. The vehicle was not yet repaired. The manufacturer was notified of the failure, and a case was filed. The failure mileage was approximately 125,000.

ENGINE · FUEL/PROPULSION SYSTEM

Vehicle Information: 2018 Jeep Grand Cherokee Overland 3.0L V6 EcoDiesel 4x4Component Affected: Fuel/Propulsion System (High-Pressure Fuel Pump) Safety Incident Narrative: The vehicle previously underwent a mandatory manufacturer safety recall replacement for the Bosch CP4 High-Pressure Fuel Pump under FCA Safety Recall Z46 (NHTSA Campaign Number: 22V-406). At 111,948 miles, while operating the vehicle, the engine suffered a sudden, catastrophic mechanical failure accompanied by an immediate and total loss of engine oil pressure. This caused the engine to suddenly stall and lose all propulsion while in motion, creating an immediate and severe highway safety hazard to myself and surrounding traffic.The vehicle was towed to an authorized Jeep dealership under Repair Order #5823328. The manufacturer (Stellantis) and the dealership are currently refusing to authorize diagnostic teardown labor or a mechanical review of the internal safety recall componentry to investigate an acute internal fuel-pump shaft seal leak or residual micro-particle metallic debris from the prior campaign. An internal drive-shaft seal failure on this replacement pump architecture dumps raw diesel fuel directly into the engine's internal oil crankcase, causing severe oil dilution, an immediate collapse of structural oil pressure, and catastrophic engine seizure. The manufacturer is attempting to shift 100% of the financial burden ($25,000 engine replacement cost) onto the consumer, actively obstructing an essential safety failure investigation into a federally recalled component.

POWER TRAIN · ELECTRICAL SYSTEM

The transmission goes into neutral. It has gone into neutral on the highway,local streets, also from a stop. From a stop in drive the electronic D on the instrument panel starts flashing. I turn on the hazards put transmission shifter in Park and start engine. This problem is intermittent, it can be cold or hot, it has happened 4x in 2 years. No accidents thankfully. The engine does not stall, the transmission goes into neutral.

POWER TRAIN

I was initially traveling at the posted speed limit of 65 when all of a sudden the engine started shaking profusely, and I lost total power of the vehicle. Therefore, I had to immediately jump onto the shoulder without being rear ended and come to a complete stop while trying to coast safely to a place so I wouldn’t be hit by traffic . My car was then brought to the local Jeep dealership and they had told me that my left camshaft needs to be replaced also the lifters rockers and oil cooler need to be replaced as well. I have not drove my vehicle since it’s been seen by the dealer , I was told that any type of Driving could completely mess up my engine, so it’s been sitting for a couple of months .

UNKNOWN OR OTHER

Went for an oil change and learn the cooler has a leak. Car was getting over heated. What cause this issue as I just got it in Feb.2026

Carry Handle · Shell · Base · Chest Clip · Buckle · Harness

This car seat does not click into the base properly and I cannot loosen the straps properly. This form does not let me upload videos however, I do have video evidence of both malfunctions happening

ENGINE

VEHICLE & PURCHASE DETAILS: 2018 Jeep Grand Cherokee (3.6L V6 Pentastar Engine). Purchased on/around April 27 in agreement with my credit union. INCIDENT & DEFECT DESCRIPTION: Upon taking delivery, the vehicle immediately displayed diagnostic warning codes. The selling dealer attempted diagnosis/repair for a week before directing me to take it to Bonham CDJR in Bonham, TX. Bonham CDJR cleared the codes and returned the vehicle. A couple of weeks later, while my wife was driving home, the engine suddenly and severely overheated without warning. I instructed her to pull over immediately to prevent engine destruction or stall in active traffic. My wife was stranded on the roadside in extreme Texas heat until a flatbed wrecker towed the vehicle back to Bonham CDJR. WARRANTY OBSTRUCTION & KNOWN FAILURE POINT: Upon arrival at Bonham CDJR, I informed service advisors that my third-party warranty provider (First Guard) would handle coverage. However, the dealership demanded a $1,300 upfront, out-of-pocket engine teardown fee just to "prove" the cause of failure to the warranty company. The 3.6L V6 Pentastar platform is notorious for cracking plastic oil filter/cooler housing units and failing thermostat assemblies, causing rapid coolant loss and overheating. Requiring consumers to pay massive teardown fees out-of-pocket to diagnose a known, unaddressed manufacturer design flaw creates an administrative barrier that leaves defective, dangerous vehicles on the road. SAFETY HAZARD & IMPACT: Sudden engine overheating at driving speeds causes sudden power loss, severe traffic hazards, thermal fire risks, and roadside stranding in hazardous ambient heat. This ongoing ordeal has caused severe personal distress, financial strain, and loss of wages. REQUESTED ACTION: I request NHTSA open a safety defect investigation into 3.6L Pentastar engine cooling failures and mandate a manufacturer recall with consumer repair reimbursement.

FUEL/PROPULSION SYSTEM

I own a 2018 Jeep Grand Cherokee EcoDiesel that has experienced repeated high-pressure fuel pump (HPFP) failures despite completion of the NHTSA HPFP safety recall. After the recall was performed, my vehicle developed the exact failure described in the recall. Metal contamination was found in the fuel system, requiring replacement of the HPFP and major fuel system components. Approximately 13,000 miles later, during routine fuel filter maintenance, I suspected the failure had returned. I asked the dealership to inspect the fuel filters for metal contamination, but they declined. I then removed and cut open the filters myself and documented visible metal shavings consistent with the recall failure. This is the second occurrence of metal contamination after the recall repair. I retained the filters, saved fuel samples, and documented everything with photos and video. I provided this evidence to the dealership and Stellantis. A STAR case was opened, but the Stellantis District Manager instructed the dealership not to perform any repairs because the vehicle has no check engine light and remains operable. The recall warns that HPFP deterioration can contaminate the fuel system and cause a sudden loss of engine power, increasing the risk of a crash. It also states this failure may occur without warning lights. My concern is that Stellantis is requiring complete pump failure before authorizing repairs, despite documented evidence that the recall failure condition has returned. I still possess the contaminated filters, fuel samples, photographs, video, and service records and will provide them upon request. I respectfully request that NHTSA investigate whether the recall remedy adequately corrects this defect and whether Stellantis' refusal to repair a vehicle exhibiting the same safety-related failure condition is appropriate.

UNKNOWN OR OTHER

while driving the car puts itself in park, then the gear shift D starts blinking and the dashboard says put into Park. I've took it to jeep to figure it out and fix it. i got it back and while on the highway it did it again causing me to almost get hit by several cars. I was on the highway doing the speed limit and no brake lights also when it happens. I took it back to jeep and they still have no clue but my jeep is to dangerous to drive period. There are not warning signs when it happens.

UNKNOWN OR OTHER

My mother went to open the door and the plastic covering of the handle had some how chipped or melted and she sliced her pointer finger down the middle. There was a massive loss of blood and she is anemic.

AIR BAGS

I was traveling south on Lee Jackson hwy in Staunton Va at about 40 to 45 mph and was t-boned on the right passenger side with the impact just in front of the passenger door and front quarter panel. The damage ended up being all the way to the right rear passenger door. None of the air bags or side curtain airbags deployed.

ENGINE

* Upon normal driving the vehicle suddenly began to run rough. At that point the engine light came on and began flashing. Yes, it is available for inspection * I was traveling at highway speeds with my two young son's in the vehicle, when out of nowhere we experienced a major loss in power, Forcing us to get to the far right lane and off on the next exit. * The problem has been Confirmed (Passenger Side intake camshaft has 5 out of 6 lobes significantly worn off. .119" of material missing as well as 2 holes on cylinder 6 piston. * It was inspected by and independent mechanic who discovered the damage to the camshafts and the piston. It was suggested that I return the vehicle to the dealer as it would be needing a new motor seeing as the damages were premature and catastrophic in nature. Upon initial inspection at the dealer, they failed to identify the 2 holes in cylinder 6 piston. Suggesting that the "said holes" were nothing other than flaked carbon deposits. * There were no warning lights or any symptoms that would have indicated anything was wrong.

ELECTRICAL SYSTEM · FORWARD COLLISION AVOIDANCE

The Cruise control pacing/follow option does not slow down/break and will rear end/strike any vehicle. The auto breaking does not work. The touch screen constantly cycles randomly changing map directions, radio stations, heat and air conditioning, seat heating and cooling. Puts driver at risk due to constant changes and alert sounds.

AIR BAGS · SEATS · UNKNOWN OR OTHER

While driving my 2018 Jeep Grand Cherokee Limited 4x2, the driver side Active Head Restraint deployed without any collision, rear impact, crash, or other triggering event. There was a sudden loud bang directly behind my head, which startled me and created an immediate safety distraction while the vehicle was in motion. I did not know what had happened at the time. The head restraint remains deployed/open and cannot be reset. The vehicle was not involved in a crash, there was no rear impact, and there was no airbag deployment. FCA/Stellantis has issued an X88 Active Head Restraint warranty extension for certain Jeep Grand Cherokee vehicles involving inadvertent deployment of the front Active Head Restraint where it cannot be reset due to internal damage. My vehicle appears to have experienced the same failure mode, but Jeep/Stellantis has advised that my VIN does not qualify for X88 coverage, apparently because the vehicle was built after the selected warranty extension population. My vehicle build date is January 2018, with MDH 011623. I am filing this complaint because this was a safety related head restraint failure that occurred while driving without a collision. The sudden deployment caused a loud impact immediately behind my head and created a dangerous distraction. I am concerned that vehicles outside the current X88 warranty population may still be experiencing the same inadvertent Active Head Restraint failure. The vehicle was factory ordered and delivered in February 2018, which may explain the later January 2018 build date, but it is still a 2018 Jeep Grand Cherokee and appears to have experienced the same inadvertent Active Head Restraint failure mode described in FCA’s X88 warranty extension.

ENGINE AND ENGINE COOLING · EXTERIOR LIGHTING · STRUCTURE

See attached document for complaint.

UNKNOWN OR OTHER

My daughter that is [XXX], her in the passenger seat, me driving were traveling down a street. I slowed to enter a turn lane going maybe 10 mph and heard a loud bang. I said "what was that noise." I glanced at my daughter she looked dazed and said "I don't know but something slammed into the back of my head." I pulled in where we were going and looked to find the head rest was popped open behind her head. There were no bumps, no impacts and not even high speed. This headrest mechanism literally deployed for no reason slamming at high speed into the back of her head and neck. I stopped called Mopar and made a complaint because it was right at 5pm and dealers were closing. She was slurring speech, dazed and repeating herself. Took her to the urgent care that sent me to the ER out of concern. They told me she may need head and neck images. The doctors and staff were so confused as to what I was even talking about. I showed them photos so they could see the situation. I was in the ER with her for 5 hours. She has a concussion. THESE HEADRESTS ARE DANGEROUS AND JUST INJURED A MINOR. WHAT DO YOU MEAN WE ARE NOT CALLING FOR RECALL. THIS ISNT JUST ABOUT EQUIPMENT REPLACEMENT. THIS INJURY COULD HAVE BEEN WORSE AND THERE IS OBVIOUSLY SOMETHING FLAWED HERE. I HAVE SEEN MANY OF THE SAME STORY. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ELECTRICAL SYSTEM · EXTERIOR LIGHTING

Headlight beams do not function. Beam lights come on upon starting car then turn off moments after. Then I am driving done the street in complete darkness. I have taken the Jeep to the dealership of purchase ( Elmhurst Chrysler/jeep/dodge Elmhurst Illinois 630-834-8000 ) 4 times over several months. They have confirmed the problem. Two days ago they had me replaced the battery. There was NO messages or other warnings that the lights have failed.

SERVICE BRAKES

I was backing up my trailer and placed the jeep in park and set emergency brake while on an incline. I got out of the jeep and the vehicle proceeded to roll away approximately 3 feet. I jumped back towards the drivers seat to press the brake to stop it from rolling down the hill

ENGINE

Cylinder Misfires OBD-II code P0303 Engine Overheats after changed thermometer Fuel in the coolant system Coolant leaking from exhaust

AIR BAGS

While driving my Jeep Grand Cherokee, the front passenger headrest suddenly deployed forward with a loud popping/exploding sound. There was no collision, no impact, and no warning before it happened. Fortunately, no one was sitting in the passenger seat at the time. If a passenger had been seated there, the headrest could have struck them in the back of the head or neck and potentially caused serious injury. This appears to be a dangerous safety defect involving the Active Head Restraint system. Based on information I found from other Jeep Grand Cherokee owners reporting similar failures, the issue may involve a faulty plastic bracket or internal component in the Active Head Restraint that can fail under pressure and cause the headrest to deploy unexpectedly. Other owners have reported injuries such as head, neck, and concussion-type injuries from similar incidents. I am concerned that this failure happened during normal driving conditions and without any crash or trigger event. This creates a serious risk to vehicle occupants and could also startle the driver, potentially causing a crash. I am requesting that NHTSA review this issue and determine whether my vehicle is affected by an existing recall or whether additional investigation or recall action is needed.

AIR BAGS · SEATS

The active head restraint on my driver seat deployed and pushed my head forward suddenly. I could not push my head back into position. This happened while driving on the evening of May 3. I have a 2018 Jeep Grand Cherokee Laredo. I was not able to reset the head rest position. I took the vehicle to the dealership. They said that the whole headrest needed to be replaced. It could not be reset because the molded plastic piece was degraded. From a search online this appears to be common in the 2014-2018 Jeep Grand Cherokee with active head restraints. Even though this is a failure of the equipment, and other Jeep Grand Cherokees from 2014 -2018 received a 10-year extension on their head restraints, the dealership and Jeep Customer Care said that my vehicle is not covered. Nor will they let me buy a seat from them that does not use the active head restraint. They said that because My vehicle's VIN specifies a vehicle with active head restraints, they cannot sell me otherwise. I will not be comfortable driving this vehicle again with an active head restraint that could randomly fail and punch my head forward while I am in rush hour traffic. I believe this is a safety risk as it is disorienting to not know why your head is suddenly pushed down and forward while you are driving at 45 mph. Distracting the driver in such a way endangers the driver, passengers, and other vehicles' occupants on the same roadway. It throws off your view of the roadway and your mirrors. There were no warnings ahead of time.

POWER TRAIN · ENGINE · FUEL/PROPULSION SYSTEM

On 5/72026@app 3:14pm after picking up one grandchild, and at a stop light on the way to p/u the other, the Jeep without warning just disengaged when the gas pedal was depressed, but to no avail. While frozen, the dashboard may have displayed something that was not noted in the panic to get the car moving! The internal panel was still illuminated, however the car would not move forwards although still in "Drive" with nothing having been switched, shifted or toggled except engagement of the brake to stop at the traffic light. The Jeep had to be placed in "Park", the starter button pressed, then pressed again to completely restart the vehicle. This was a potentially huge safety issue with many cars around us honking & rushing to pick up their own children, yet fortunately no one ran into us with our precious little rider!

UNKNOWN OR OTHER

The uconnect system or radio that has all the digital controls on it.Seems to do what it wants to whenever it wants to. It appears the delaminating underneath the the screen cover. Hey, it actually dialed 911, while my girlfriend borrowed my vehicle.A few weeks ago.

ENGINE

There are parts in the engine that malfunctioned and have caused fluids to leak into the engine. This is causing the engine to fail and requiring replacement. This issue started last year for me personally. The car has been to 2 mechanics and they both have diagnosed the issue , and to fix it requires full engine replacement . It’s a safety issue because the engine can lock up and stop the car.

ELECTRICAL SYSTEM · ENGINE · FUEL/PROPULSION SYSTEM

I recently purchased a 2018 Jeep Grand Cherokee and began experiencing serious issues almost immediately after taking possession of the vehicle. The vehicle has stalled unexpectedly while driving on multiple occasions, including during active driving conditions. It also has difficulty starting and has shut off without warning. The vehicle has already undergone multiple repairs within a short period of time, including work related to the radiator, spark plugs, and ignition coil. Despite these repairs, the issues continue. This creates a significant safety concern, as the vehicle becomes inoperable without warning, especially during daily highway driving. I rely on this vehicle for transportation, and it is currently unreliable and unsafe to operate.

POWER TRAIN

Twice I have been driving on the highway at 60 mph and the transmission had suddenly shifted into low gear and subsequently went into limp mode. The dealer is unable to find an issue with the vehicle. There were no warning lights, before, during, or after. After I pulled onto the shoulder of the road and turned the Jeep off and turned it back on it operated normally.

ELECTRICAL SYSTEM · UNKNOWN OR OTHER · ENGINE

had a recall done in February and 3 weeks later the car would not start randomly no warning lights illuminated on the dash prior to being shut off and once it would start it threw 3 codes for p0850, u0100, and U1267 all related to the parts replaced in February for the recall for the 2nd time now regarding the same parts. and trying to get a reinspection done for the recall bc the parts seem to have failed and its been a living nightmare. and unsure why no warning lights were illuminated prior to the car not starting randomly

ELECTRICAL SYSTEM · SEATS

Electrical goes crazy when driving and parked , radio comes on, switches from AC to heat , on its own , calls people in my contact list , calls 911, screens goes blank at times , flashes on and off , heated seat on driver side gets way to hot , passenger seat ok so far , headlight keeps going out on passenger side fails to get it off heated seats at times or it freezes, it jumps from defrost to vent to floor , heat to AC , have to turn on AC when it rains to keep windows from fogging up. Hard to drive when it’s lighting up like a Christmas tree , radio won’t stay on same station , jumps from station to station , when on speaker phone it mutes the calls, or hangs up the person you are talking to. Navigation won’t work most of the time freezes up also.

ELECTRICAL SYSTEM · UNKNOWN OR OTHER · SERVICE BRAKES

Recall on the hydraulic control unit/anti-lock brake system A brake light incorrectly resulting other drivers not receiving proper indication to stop or slow down which can cause a vehicle crash without prior warning. Call my local dealership and MOPAR and informed me that they still do not have the part to fix this recall. It has been more an an year and half without resolution. They have not inspected my vehicle as I did schedule an appointment but the dealership informed me that they is still no solution and would reach out. There has no warning lamps or messages that appears in my vehicle as of right now.

ENGINE

Check Engine light with Codes: PO300, and PO305. Misfire in Cylinder #5. Changed all spark plugs, and coils. Check engine still on, with same codes. Jeep dealer then said it was the cam shaft and needed new cam shaft head of a price tag of $8500. The car has been well maintained and has 75,200 miles on it. There is a known premature failure with the Pentastar Engine that is in this vehicle. Jeep is refusing to stand behind their product.

ENGINE

The contact owned a 2018 Jeep Grand Cherokee. The contact stated that while unloading groceries out of her vehicle with the vehicle in park(P) and the engine on, grayish-white smoke began to emit from the vehicle without warning. The contact turned off the vehicle and checked under the hood, where she saw flames in the engine. The contact then ran to the fire department, which was nearby, and informed them of the fire. The fire department arrived at the scene with a fire truck and extinguished the fire. The police department also arrived at the scene, and a police report was filed. No injuries were reported due to the fire. The vehicle was destroyed as a result of the fire, but was not towed. The dealer or manufacturer had yet to be notified of the failure. The vehicle was not repaired. The failure mileage was approximately 74,000.

ELECTRICAL SYSTEM

The contact owns a 2018 Jeep Grand Cherokee. The contact stated that while driving at an undisclosed speed, the “Service air Suspension” warning light was illuminated. In addition, the contact stated that the headlights independently turn on and off, the doors independently locked and unlocked, and the radio independently changes stations. In addition, the contact stated that the failure caused the headlights to burn out prematurely. The vehicle was taken to the dealer; however, the failure was not duplicated. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The contact was later informed that there was moisture in the wires. The contact was informed that the moisture had been cleaned from the wires. The contact was informed that the vehicle was repaired. The contact disagreed with the diagnostic test and the repair. The contact stated that the failure was a known failure with the vehicle. The manufacturer was not made aware of the failure. The failure mileage was approximately 80,000. The VIN was unavailable.

ENGINE

1. The issue involved the engine and emissions system, specifically a cylinder 3 misfire, accompanied by illumination of the check engine light and white smoke emitted from the exhaust. The vehicle was evaluated by an authorized Jeep dealership, which confirmed the cylinder misfire through diagnostic testing. At that time, per the diagnosis, coil 3 and all spark plugs were exchanged. This did not solve the issue. When picking up the car, check engine light was still illuminated and white smoke emitted from the exhaust. The affected components are in possession of the dealership, unsure if available upon request. 2. The engine misfire and associated white exhaust smoke created a risk of engine performance degradation, including potential loss of power, observed hesitation and stalling, which could impact the ability to safely operate the vehicle in traffic. Additionally, white smoke from the exhaust can impair visibility for surrounding drivers and may indicate an underlying engine condition that could worsen without warning, increasing the risk to the driver and others sharing the roadway. The chemical smell could also nauseate the person operating their vehicle, impeding their awareness and concentration. 3. This issue was proposed by an authorized Jeep dealership, then confirmed by two other mechanics. Dealer diagnostic records document the cylinder 3 misfire and investigation related to the check engine light and exhaust condition. 4. No inspection from manufacturer, police, or insurance representative. 5. Yes, the check engine light illuminated and the vehicle exhibited white smoke from the exhaust which prompted the service visit. Auto-start was not functioning as normal, with an error displayed on screen. Engine would sometimes stall upon start up during cold temperature days. NOTE: vehicle is currently with another mechanic awaiting an engine replacement, will upload that invoice once available.

POWER TRAIN

While driving on the highway I received a “SERV 4WD” light and also a traction control unavailable light. Other than that that the car appeared to drive normally other than I could feel the car gears “catching” at starts when I pressed the accelerator. I took the car to the certified dealer and they said it was a transfer case failure and was unsafe to drive as it could have caused the wheels to lock up. This issue is very similar to a recall for other Jeep VINs over the same production timeframe of my Jeep, although my VIN was not included in that recall. I am seeking the immediate inclusion of my VIN into the Jeep recall that exists for manufacturing defects of the transfer case.

POWER TRAIN

The contact owns a 2018 Jeep Grand Cherokee. The contact stated that while driving at 20 MPH, the vehicle failed to accelerate as intended while depressing the accelerator pedal, and the vehicle stalled. The vehicle was restarted, and a short distance later, the failure persisted. The contact stated that there were several attempts to restart the vehicle. However, the failure persisted. The message "Shift to P then Desired Gear" was displayed. The contact continued to drive and arrived at the workplace. The contact stated that prior to the failure, the vehicle jerked while driving. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 25V011000 (POWER TRAIN). However, the VIN was not included in the recall. The manufacturer was notified of the failure. The failure mileage was approximately 44,000.

VEHICLE SPEED CONTROL · ENGINE

Had the ABS Module repaired due to recall last week. Next, I have had 3 instances of the Accelerator sticking when shifting gears and, this never happened before this service.

SEATS

To Whom It May Concern, I am writing to formally report a serious safety defect regarding the Active Head Restraint (AHR) system in my vehicle. On 11/28/25 the headrest deployed spontaneously while I was operating the vehicle. Incident Details: • No Collision: There was no impact, collision, or sudden braking event that would trigger a safety deployment. • Safety Risk: The forceful deployment occurred without warning, striking me in the back of the head. • System Failure: The internal plastic bracket responsible for holding the spring-loaded mechanism failed—a documented issue in many similar Stellantis vehicles. I contacted a certified Jeep dealership and Stellantis customer service regarding this failure. They have declined to provide a remedy, repair or reimbursement the component under any "goodwill" or extended warranty program, stating that my specific VIN is not included in existing service bulletins or recalls. Request for Action: The "VIN-specific" limitation is arbitrary when the mechanical failure is identical to those in recalled units. A safety component that deploys violently without an accident is a defect, regardless of whether the manufacturer has acknowledged that specific production batch yet. I request that the NHTSA investigate this failure as part of an expansion of existing inquiries into Stellantis AHR systems. I have attached photos/repair quote of the deployed unit for your records. Sincerely,

POWER TRAIN

Front passenger side CV Axle purchased from detroit axle. They confirmed on website it would fit my make, model, and year of vehicle. Once I described that they are selling this part incorrectly and they refused to change website to continue fraud sell I asked for a full refund. They denied and said I'd be deducted shipping costs. If this part would've almost fit I'd have been a risk for life on the road for myself and others. They refuse to fix this safety and fraud violation on their website.

SUSPENSION

The front air springs, struts, and air suspension compressor failed. The dealer cannot get the right front air spring because it is backordered. It appears that 100% of these components fail creating demand that the manufacturer cannot keep up with. There should be a recall at this high failure rate on a component that makes the vehicle unsafe to drive per the warning on that dash.

ELECTRICAL SYSTEM

Upon vehicle start-up, the Uconnect screen will freeze up. Placing the vehicle into reverse, the back-up camera is not shown. During the issue, the screen could be frozen/not responsive, or a blue screen. This concern has been an ongoing issue for some time now. It seems to be getting more frequent recently.

AIR BAGS

AIR BAG LIGHT LIGHT IS ON DOES NOT SHOW UP ON DIAGNOSTIC

ENGINE

Issue with camshaft. Dealership said there has been an influx of vehicles with the same engine and the same issues.