2021 TOYOTA RAV4 reports

UNKNOWN OR OTHER

I am reporting a serious safety concern involving the sunroof glass on my 2021 Toyota RAV4 Hybrid Limited AWD. On July 3, 2026, at approximately 37,350 miles, I was driving the vehicle when the entire sunroof glass suddenly and catastrophically shattered. There was no traffic around me, there was no debris in the roadway, I was not traveling under an overpass, and I am not aware of any impact or other event that could have caused the glass to break. The failure was completely unexpected. I heard a very, very loud sound, similar to a gunshot. Immediately afterward, the entire sunroof glass had shattered into small granules. A very small piece of shattered glass also flew off the vehicle. I was able to quickly close the interior sunroof visor, which fortunately prevented the majority of the shattered glass from falling into the passenger compartment and prevented injury. There was nevertheless some glass that fell into the roof liner. I immediately contacted my insurance company and the car was towed to my Toyota dealership. The sunroof was replaced with a Toyota original part and the replacement was paid by my insurance company. This incident created a significant safety hazard because the sunroof glass failed suddenly and violently while the vehicle was being driven. The extremely loud explosion-like sound and the sudden loss of the sunroof glass could cause a driver to lose control of the vehicle or could result in glass striking occupants. In this instance, I was fortunate that the visor was closed quickly and that there was no surrounding traffic. I believe NHTSA should investigate whether there is a defect or other safety-related problem with the sunroof glass or its installation in this vehicle, particularly if similar spontaneous breakage incidents have occurred in other Toyota RAV4 vehicles. I am reporting this incident because the glass appeared to fail spontaneously, without an apparent collision, road debris, overpass, or other external impact.

STEERING · POWER TRAIN · ENGINE

2021 Toyota RAV4 gas XXX Vehicle suddenly stopped while driving Busy roadway in [XXX] Wife and young children were passengers Dashboard displayed “ENGINE STOPPED” Dashboard displayed “STEERING POWER LOW” Police responded Police determined waiting for the insurance tow was unsafe Police arranged emergency towing Vehicle subsequently inspected by Beaver Toyota Dealer drove approximately 26 miles attempting to reproduce the issue No fault code/history found Problem could not be reproduced You remain concerned about a potentially recurring safety defect INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ELECTRICAL SYSTEM · UNKNOWN OR OTHER · ENGINE

I have a faulty coolant bypass valve on my 2021 Toyota RAV4. Every time I turn on the air conditioning the service engine required comes up on my notifications a known recall problem for Toyota RAV4’s of this year

POWER TRAIN · ELECTRICAL SYSTEM · ENGINE

2021 Toyota RAV4 (gas model) has experienced a sudden, unexpected engine stall/shutdown on a public road. The incident occurred while shifting into Drive after backing up in reverse. The engine immediately died without any prior dashboard warning lights or mechanical symptoms. The information screen displayed a message stating "Put Car in Park" or "Shift into Park." The vehicle safely restarted immediately after shifting back into Park and pressing the ignition button. This intermittent stall has happened three times under the exact same directional shifting conditions over the last 1.5 years, creating a high-risk scenario for a rear-end collision in active traffic. After previous incident (one year ago) when the engine stopped when shifting from reverse to drive, I took it to Toyota service. Dealership diagnostics could not previously replicate the issue due to its intermittent nature and the absence of a permanent check engine code. checked battery and performed health check.

SEATS

The driver’s seat adjustment mechanism failed and the seat became stuck, unable to move forward or backward. We initially went to a Toyota dealership and told them we believed the issue was a broken gear in the seat rail assembly. The dealership stated they needed to complete their own diagnostic assessment before proceeding, which would cost approximately $275 and add delay, despite already being told the likely cause. We instead took the vehicle to an independent mechanic, who confirmed the cause was a broken gear/synchronizing mechanism in the seat rail assembly. The mechanic confirmed that Toyota is the only source for this replacement part — it is not available from third-party or aftermarket suppliers — and has ordered the part directly from Toyota, at a cost of approximately $1,500, to install himself. This creates a safety risk because the driver is unable to adjust the seat position to reach the pedals and steering wheel properly, and cannot reposition the seat in the event of an emergency requiring rapid exit from the vehicle. Seating position also affects airbag deployment safety, since proper occupant positioning relative to the airbag is a factor in crash protection. There were no dashboard warning lights or error messages prior to the failure. The seat simply stopped moving on one side during normal, everyday adjustment. This appears to be a widespread and recurring issue rather than an isolated incident. Numerous other owners of 2019–2024 Toyota RAV4 vehicles have reported the identical failure — a broken gear in the seat rail mechanism — on Toyota owner forums and online community discussions, many describing the same high repair cost tied to the fact that only Toyota sells the necessary part. The vehicle is a 2021 Toyota RAV4 with approximately 56,000 miles at the time of failure. The component is available for inspection upon request.

VISIBILITY · SEATS

The contact owns a 2021 Toyota Rav4. The contact stated that while driving at an undisclosed speed, the front driver’s seat became stuck. No warning lights were illuminated. The failure reoccurred on several occasions. The contact stated that water was leaking into the vehicle from the front driver’s and passenger sides, causing puddles of water in the front driver’s and passenger’s seats with an abnormal odor. The contact stated that the leak was near the bolts and screws. The failure reoccurred on several occasions. The vehicle was taken to an independent mechanic, who advised that the water leak could not be repaired and that the condition was unsafe. The vehicle was not repaired. The vehicle was taken to a dealer where it was diagnosed and determined that the A/C system and several other unknown components needed to be replaced. The dealer stated that the vehicle was out of warranty. The vehicle was repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was unknown.

LATCHES/LOCKS/LINKAGES

The driver side door actuator will not work, car is only five years old. Door will not unlock from fob, door unlock button or app. Began with a few random instances of not unlocking then turned into never unlocking again. Would have to climb through the passenger side to manually unlock by pushing switch. Got the actuator replaced but now car will not allow opening from inside, have to climb out of passenger door. This is a major safety concern as being unable to open a door in an emergency can be life threatening. The problem was reproduced and repair quoted by dealership. Problem was also reproduced by local mechanic and part replaced by them. Component inspected by manufacturer. The only warning was it sometimes not working, this began a few months back around February 2026.

POWER TRAIN · UNKNOWN OR OTHER · ENGINE

My 2021 Toyota RAV4 began experiencing intermittent shuddering and vibration at low speeds around May 2026. The condition occurred while accelerating from a stop or at slow speeds and became more frequent over time. Because the problem was intermittent, the dealership was initially unable to duplicate it. Independent inspection later found dark transmission fluid containing metal debris, indicating internal transmission failure. I was informed the transmission requires replacement or rebuild. My vehicle has approximately 94,000 miles, which is well below the expected service life of a modern transmission. The symptoms are consistent with numerous reported complaints involving Toyota’s UA80 automatic transmission and torque converter. An unexpected loss of smooth power delivery or hesitation during acceleration creates a potential safety risk, particularly when entering traffic or crossing intersections. I am submitting this complaint so NHTSA can investigate as this is a very dangerous and concearning issue.

VEHICLE SPEED CONTROL · ENGINE

The contact owns a 2021 Toyota Rav4. The contact stated that while driving at approximately 30 MPH, the vehicle aggressively accelerated while the accelerator pedal was depressed. No warning light was illuminated. The vehicle was taken to a local dealer and remained with the dealer for additional diagnostic tests. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 60,000.

UNKNOWN OR OTHER

The sunroof exploded spontaneously while I was driving. It sounded like a gunshot. There were no other vehicles around, so it wasn't caused by a stray rock. It was only 73 degrees, so I don't think it was heat related.

AIR BAGS

I have been unable to get my vehicle inspected and repaired by a dealer despite months of waiting and asking two different Toyota dealers to order the necessary part or parts. This recall has been in place for years. For several years I was told it was only being done in certain states and that New Mexico would be last on list due to climate. Probably six months ago the message changed from Toyota and it was now ok in every state. Only problem is still no parts according to dealer. Last contact was on June 2, 2026 with the second dealer to order part. No call back and no contact. First effort was in Santa Fe NM where car was purchased new in 2021at Toyota dealer. Last effort over a month ago was at Albuquerque Larry Miller Toyota. So safety recall for faulty air bag sensor on my wife's side of car has been in place about 900 days without parts to fix a potentially deadly problem. VERY DANGEROUS

UNKNOWN OR OTHER

What component or system failed, and is it available for inspection? The roof/water sealing system failed, allowing water to enter the vehicle interior. It is available for inspection upon request. How was safety put at risk? Water intrusion through the roof caused visible mold growth, interior deterioration, and a severe foul odor. The mold and contamination inside the vehicle is causing constant illness to the occupant, creating a serious ongoing health and safety hazard. Has the problem been reproduced or confirmed by a dealer or service center? The vehicle was brought to a service center for inspection, however they refused to inspect it. The problem has not been formally confirmed. Has the vehicle been inspected by the manufacturer, police, insurance, or others? The vehicle was taken in for inspection but the dealer/service center declined to inspect it. No manufacturer, police, or insurance inspection has taken place. Were there warning lamps, messages, or symptoms prior to failure? When did they first appear? No warning lamps or messages appeared. The symptoms that developed include: Water entering through the roof Visible mold growth Interior deterioration Severe foul odor described as "rotten rat" smell Occupant experiencing constant illness due to exposure

LATCHES/LOCKS/LINKAGES

The front driver-side door lock and opener (actuator) stopped working using the key fob and needs to be manually locked from the inside. When I try to access the door after manually locking driver side and using my key fob for the remaining 3 locks, the unit won't automatically open. This causes a safety risk considering I need to access the driver's side back or front passenger side to open the door. According to what I've read this is a known issue.

LATCHES/LOCKS/LINKAGES

Passenger front door actuator\lock mechanism does not lock/unlock the door. There have been numerous lawsuits and yet NO RECALL for this very dangerous known problem. Please advise if there is any assistance from Toyota available to cure this defect that is well known to exist. I can be reached @ [XXX]. Thank you in advance for your assistance, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

AIR BAGS

The contact owns a 2021 Toyota RAV4. The contact was traveling at approximately 50 MPH directly behind a van in the same lane of traffic. The van suddenly made an emergency avoidance maneuver to bypass a stationary vehicle completely stopped in the lane. Despite the attempt, the van rear-ended the stopped vehicle. The contact immediately initiated an evasive maneuver to avoid the sudden collision occurring ahead. However, due to proximity and immediate lane obstruction, the contact was unable to avoid an impact and struck the vehicle. The severe front-end impact resulted in catastrophic damage to the contact's vehicle before it came to a complete stop. The airbags failed to deploy, and no warning lights were illuminated. The vehicle was towed to a repair shop. A police report was filed. The driver and her pet were the only occupants of the vehicle, and the contact was the only injured passenger. The contact sustained moderate chest pain, but no medical assistance was received. A police report was filed. The dealer was not notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 62,000.

VISIBILITY/WIPER

was driving on 4 lane hwy and it was raining and my wipers stopped working mid-way on windshield, I had to find a safe place to pull off road and inspect the problem i tried turning car off and back on and wipers would still not work. I drove another 3 miles or so to the Toyota dealership luckily with no accident which made me feel very unsafe without my wipers. They told me i would have to leave car for them to take panel off to find the cause of failure and provided a loaner after i refused an Uber.

AIR BAGS

The contact owns a 2021 Toyota Rav4. The contact received notification of NHTSA Campaign Number 23V865000 (Airbags) however, the part to do the recall repair was not yet available. The local dealer was/was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was/was not made aware of the issue. The contact had not experienced a failure.  The VIN was invalid./The VIN was not available.

UNKNOWN OR OTHER

Water sloshing around inside the passenger door after rain or car wash. If you pull at the seal a little bit, water pours out. This has happened a few times now in the last year of owning the car. The rear seatbelt sensor also goes off randomly, when no one is sitting in the back seat.

POWER TRAIN · LATCHES/LOCKS/LINKAGES

Gear shift makes noise when moving it, as in you can actually hear the gears/electrical equipment moving and making noise when going from park to drive. The keyless entry when the fob is near, just doesn't work well from the drivers side... I can stand there trying to allow it to unlock and it just locks again or wont unlock the passenger door even if allowing it extra time to.

POWER TRAIN · ELECTRICAL SYSTEM · WHEELS

Car makes a whining noise Toyota Pinellas park said it was normal but the transmission is jolting/slipping not accelerating vs the first test drive. Both cv axles were bad tires were bald when sold to me tps sensors were bad. Had to get a new set of tires and paid the Toyota for work on the vehicle

STRUCTURE

The car had to be resealed and had water damage. The car smelled like mildew when I purchased it. Water was getting in the car and they resealed it but it does not rectify that the car had water damage due to the leak in the seals

ENGINE

“Required Engine Maintenance- Visit Your Dealer” message came on the dash. After doing some research and troubleshooting; it appeared to be the coolant bypass valve that everyone has had issues with. The problem was then confirmed with a local provider who instructed us to contact the dealer to see if they’d cover the repair. Otherwise the repair by them would be $700. Toyota customer service told us that there is no TSB or Recall for this issue. We would need to have the issue diagnosed and then pay out of pocket for the repair. This is an issue that spreads throughout so many vehicles that it needs to be a recall.

ELECTRICAL SYSTEM · UNKNOWN OR OTHER · ENGINE

Upon taking my 2021 Rav4 Hybrid in for the rear traction motor cable corrosion recall (25TD01) on 5/7/2026, I was told there are no parts, no estimated arrival time, and therefore not even a rough estimate for a timeframe of repair. I was told that no one would inspect or evaluate the part in question to indicate if the car was safe to drive. I expressed my extreme concern given the recall includes risk of power failure, even while driving. I received inconsistent, avoidant answers and an absolute denial to remedy the situation in any way. I was told the dealership is "Dolan" and not "Toyota". I again expressed my concerns about safety and the dealerships' denial to, at minimum inspect the recalled part and/or housing of the part. Emily, the Service manager stated that Toyota does not "allow" loaner vehicles for this particular recall. She could not provide any sources for this information. To summarize; the dealer with not provide an inspection of the recalled part and/or housing, or give an estimated timeline for repair given I am #125 on a waitlist. There is a complete lack of regard for mine or my children's safety as the dealer will not provide any assessment of how bad the damage could be. They suggested that I continue to drive the vehicle, acknowledging all of the safety hazards that could occur. I am terrified of the possibility of having an accident with my kids in the car due to this recalled part failing, not having a vehicle to get to and from work, and the potential additional costs that this unaddressed recall issue could cause. Please advise!

POWER TRAIN

Transmission failed at 105,000 miles Quotes to replace $8000

SEATS

The plastic gears that make the seat move back and forth have failed so I can’t adjust the drivers seat to a proper position. We have 2 drivers of almost a foot different in height. There is a plastic gears that runs against a metal gear. Seat is unusable.

SEATS

- The seat has cheap plastic parts that move the power seat forward and backward, and once malfunction you have to change either the whole seat or the drivers seat track adjuster assembly and both of them expensive. - The seat was built poorly which cause lower and upper back pain.

SEATS

Front seat can not be moved back and forth without grinding noise.

ENGINE

The coolant bypass valve failed and the car is a 2021 Rav 4 LE. I called Toyota and according to the VIN it is not covered for this type of repair. I see quite a few cars have had this same issue, all Toyota's. It was inspected and repaired at a local Toyota Dealership but I had to pay out of pocket for the repair. There was a brief warning light that said "Engine Maintenance Required" See dealership or some such thing. Of course it's a safety issue if the coolant valve bypass failure causes the car to overheat.

SEATS

I have a 2021 TYTA RAV4 HYBRID XLE PREMIUM AWD, the driver seat is very slow moving forward and backwards twisting and preventing to fully go forward and backwards. I need to get out and in of my vehicle. So I have to move in back and forth to get out and move it forward to see over the dash board. I am concerned it makes a load noise. What if it fails to move. This is a critical danger to me the driver. I have passengers to consider. This is absolutely unsafe. This is allowed? Where is the recall? This is unlike Toyota to do nothing. I have platinum coverage purchased at time of purchase of this brand new vehicle on 12/31/2021. Apparently, it causes it other damage to other components and parts. There is alot of other components and parts under the front driver seat. I went it to have it looked at on March 30, 2026. Service advisor states: They ordered the parts its a seat frame sub assembly with motor. $1785.92 Covered by platinum Coverage, not all the parts are covered that are damaged. it will cost me: $448.87 for components and parts damaged but are not covered plus labor for Shield (71812-0R140-C0) and Holder (7181B-0R010) After further investigation it is a symptom of a failed internal component within this assembly—most commonly a stripped plastic gear or a bent drive shaft. So looking it up many Toyota Brand owners are experiencing the same thing and are having to replace other parts caused by this. This is a dangerous situation for me and others. What if it fails to move forward or reverse or motor stops? A partial repair is unacceptable. Leaving damaged trim and holders creates a risk of wire-chaffing and further mechanical stress on the new assembly. For the safety of the driver and the longevity of the vehicle, the repair must be 100% complete. This would be out of pocket monies families don't have. $2,234.79 total repair cost acts as a "safety tax" that prevents families from fixing this critical defect. I can not afford: $448.

AIR BAGS

Srs error appeared on the dash. Now the dealership is opening steering column to fix the electrical issue. The car has less than 29,000miles on it.

LATCHES/LOCKS/LINKAGES

The contact owns a 2021 Toyota Rav4. The contact stated that the front driver’s side door failed to lock securely. The contact stated that the door could not be locked while using the key fob, the keypad, or locked manually. The cause of the failure was not yet determined. The local dealer and manufacturer were not notified of the failure. The failure mileage was 108,000.

AIR BAGS

The contact owns a 2021 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was not yet available. The dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

STEERING

The steering light comes on , and "engine stopped, steering power low" comes on. The car just stops, usually when I've braked and come to a compete stop, and just completely shuts down. It's done it in the middle of traffic, I don't know why it's an issue.

AIR BAGS

I was in a car accident that ended up being a total loss for my vehicle. I was hit head on to the front drivers side and none of my airbags went off. I am aware there was a recall for the passenger airbags, and was actually scheduled to get the repair the following week, but the drivers side airbags are not included in the recall. After the collision I received an error message on my display that advised there was an airbag malfunction and to contact my toyota dealer. Thankfully I did not sustain any known injuries, however I am pregnant and none of my airbags went off appropriately.

STRUCTURE

The contact owns a 2021 Toyota Rav4. The contact stated that while driving at an undisclosed speed, there was a swishing sound coming from the front passenger’s side door. There was water inside the door's body cavity. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 70,000.

VISIBILITY

My 2021 Toyota RAV4 Hybrid exhibits significant vibration in both exterior rear-view mirrors beginning at approximately 30 MPH, worsening at highway speeds of 50–70 MPH. Toyota has acknowledged this as a known manufacturing defect via TSB T-SB-0079-20, which identifies the original mirror mounting studs and reinforcement brackets as inadequate from the factory. The condition was confirmed by my local Toyota dealership, who verified TSB applicability but declined to cover the repair due to my vehicle being outside the 36-month/36,000-mile warranty window. I am currently at 127,000 miles. The safety risk is active and ongoing. Constant mirror vibration creates two compounding hazards: it directly distorts rear visibility, and it conditions the driver to mentally filter out mirror movement as background noise. This habituation means a motorcyclist or small vehicle appearing in the mirror may not register as a distinct threat. The component is available for inspection upon request. No warning lamps accompany this condition. The vibration has been present since early ownership and has not improved over time.

AIR BAGS

The contact owns a 2021 Toyota Rav4. The contact stated that while driving on the freeway at approximately 35 MPH, another vehicle approaching from the opposite direction attempted to make a left turn and collided with the contact's vehicle. The point of impact was the front driver's side wheel well and side bumper area, with additional damage noted on the front passenger side bumper. No warning lights illuminated. The other vehicle was driving at an undisclosed speed and sustained damage to its front-end frame. There was no property damage reported. Both vehicles came to a stop in the roadway at the intersection of [XXX] and [XXX] in San Jose, California. The contact's vehicle remained drivable and was driven to the residence; towing was not required. The airbags did not deploy. The driver sustained injuries, including a fractured vertebra and a fractured sternum, and received medical treatment. The driver believes that the injuries may have been prevented if the airbags had deployed. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the issue. The contact related the failure to NHTSA Campaign Number 23V865000 (Air Bags). The failure mileage was unavailable. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

POWER TRAIN · ELECTRICAL SYSTEM · FORWARD COLLISION AVOIDANCE

My Toyota hybrid AWD vehicle experienced corrosion of the rear traction motor cable, which Toyota has acknowledged in Service Campaign 25TD01. This corrosion affects the electrical connection to the rear drive motor and can result in loss of AWD propulsion capability. Loss of rear-wheel propulsion significantly reduces traction and stability, particularly in snow, ice, and wet conditions. Drivers may believe the vehicle still has AWD capability when in fact the rear drive system is compromised. In addition, the vehicle’s adaptive cruise control system repeatedly turned off unexpectedly while driving and displayed “unavailable” warnings. These malfunctions occurred alongside the electrical issues related to the rear traction motor cable corrosion, suggesting the defect may affect multiple vehicle systems. Toyota has acknowledged this defect through Service Campaign 25TD01 but has not issued a safety recall. Given the potential for loss of propulsion and malfunction of driver-assistance systems, this issue should be investigated as a safety defect.

POWER TRAIN

The entire transmission failed according to the Toyota Service Center in Hyannis, MA. My vehicle is only 5 years old, only has 42,245 miles, no history of any accidents, I am the only owner, and had regular and consistent service. My vehicle is available for inspection. I am now part of the class action lawsuit against Toyota for knowingly selling cars with the defect in the UA80 8-speed automatic transmissions and torque converters. The transmission failed while I was on the road driving, which could have been a potentially very dangerous situation. The vehicle was inspected by the independant Ira Toyota Service Center of Hyannis. There were 5 different warning lights that suddenly came on while I was driving, and I immediately went straight to the nearest Toyota center as soon as the lights came on. Apparently, according to the class action lawsuit, engineers warned Toyota about the flaws in the UA80 8-speed automatic transmissions and torque converters, but they sold vehicles with them anyway. I am not the only victim. I informed toyota of the issue, but they will not repair it. Here is information about the class action lawsuit that many others are part of now too: [XXX] Here is another lawsuit in NJ for the same issue: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

UNKNOWN OR OTHER

The sunroof shattered without any thing hitting the glass

UNKNOWN OR OTHER

On 2/24/2026, while driving down I-5 Freeway, the panoramic sun roof spontaneously shattered while I was driving. It sounded like a gunshot. Nobody was injured. There was no accident. I pulled off the freeway and the WASDOT incident response truck pulled off with me to inspect. He taped the shattered and cracking glass until I could get to Safelite in Federal Way and get a crash wrap so glass didn't continue to fly off while I was driving. I contacted my glass repair team and he reported to me that this has happened with thousands of my toyota cars. I will be calling the dealership today.

FUEL SYSTEM · GASOLINE

The contact owns a 2021 Toyota Rav4. The contact stated that while fueling the vehicle, the fuel tank failed to register the correct fuel level. The contact stated that the fuel warning light illuminated intermittently while driving and while the vehicle was parked. Additionally, the fuel gauge displayed inaccurate readings and eventually became inoperable, leaving the contact unaware of when the vehicle needed to be refueled. The vehicle was taken to the dealer for inspection. The dealer informed the contact that the fuel tank readings had failed, and the vehicle was supposed retain approximately 14.5 gallons of fuel; it would only accept approximately 11.5 gallons during testing. The contact was further informed that the fuel tank and fuel reader had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for further assistance. The approximate failure mileage was 46,252.

STEERING

The contact owns a 2021 Toyota Rav4. The contact stated that while his daughter was driving approximately 23 MPH and attempting to make a turn, the steering wheel seized, and the vehicle sideswiped another parked vehicle. There was no warning light illuminated. The steering wheel remained seized. The air bags had not deployed. No injuries were sustained, and no medical attention was required. A Police Report was filed. The vehicle was towed to the dealer, where it was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 97,000.

SEATS

Power seat adjuster failed making it impossible for drivers to adjust the seat for safe driving.

ELECTRICAL SYSTEM · STRUCTURE

This complaint is being filed as a follow-up to a previously submitted NHTSA complaint regarding door lock failures on my 2021 Toyota RAV4 Hybrid. Since the original complaint, a second door has now failed. In addition to the front passenger door, the rear passenger-side door will no longer lock or unlock electronically using the key fob or interior power lock button and must be locked manually. When attempting to lock the vehicle, the vehicle emits a warning beep indicating a door is unsecured, even though some doors appear locked. Upon inspection, the rear passenger door was found unlocked. This issue appears to be progressive, affecting multiple doors. Doors may appear locked when they are not, creating a security concern.

ELECTRICAL SYSTEM

Driver door lock actuator. When using the vehicles remote key, the driver door does not lock and unlock with the rest of the vehicles locks. This failure can cause theft of personal property in the vehicle or theft of the vehicle itself. The problem has been confirmed by other toyota owners with similar models. No warning lights of the problem appeared.

ELECTRICAL SYSTEM · STRUCTURE

I am reporting a safety defect involving the front passenger door lock actuator on my 2021 Toyota RAV4 XLE Hybrid. The front passenger door will not lock or unlock using the key fob or the interior power door lock button. The door must now be locked manually. This defeats the vehicle’s automatic locking system and creates a safety and security concern. This condition prevents all doors from being secured properly when driving or when parked. A passenger may believe the door is locked when it is not, increasing the risk of unauthorized entry, theft, or passenger safety issues. The failure occurred during normal use and without warning. The vehicle has been properly maintained. I have learned that multiple Toyota RAV4 owners have reported similar door lock actuator failures, indicating a potential widespread defect. This issue occurred shortly after the factory warranty expired. Due to the safety implications, I believe this issue warrants investigation and possible recall or manufacturer repair program. “This failure occurred without warning and with no dashboard alerts.”

STEERING · POWER TRAIN · ELECTRICAL SYSTEM

‘Voltage abnormality, power steering low’ error message has appeared three separate times. All while vehicle is idle at stop light or parked, last incident car was unable to restart immediately. All dashboard lights came on, including message saying parking hold unavailable. Mechanic confirmed no issues with 12v battery health and unable to recreate issue. Loss of power is risk to safety, possible draining of battery due to unknown issue

SERVICE BRAKES · FORWARD COLLISION AVOIDANCE

My wife was pulling her car into a parking area consisting of a few small storefronts. When pulling in, the brakes completely failed as did the forward collision warning system and the automatic emergency braking system. As she continued to press the brake pedal it just went to the floor of the car. The end result was that the car struck one of the storefronts causing damage to the building as well as her car. Fortunately the store was closed at the time and no one was injured, nor was she. There were not any warning lamps or messages prior to the brakes failing. The brakes worked fine in the approx. 15 minute drive prior to the accident. I realize that drivers sometimes press the accelerator in error instead of the brakes and I can assure you that this was not the case (we wife is not elderly and is a very safe driver). We spoke to the auto body shop who will be repairing the car and they told us that the brakes currently seem to work. A online search revealed that this problem as been reported / discussed by others in the past. We expect to have the car repaired and returned to us in the next week but are very concerned with driving it as another accident could be fatal.

AIR BAGS

The contact owns a 2021 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, parts were not yet available for the recall repair. The local dealer was made aware of the issue and confirmed that parts were not yet available. The dealer confirmed that parts were not yet available. The manufacturer was not made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure.